Product ID:CLEANING COMPOUND, SOLVENT
MSDS Date:01/15/1991
FSC:6850
NIIN:00-209-7947
MSDS Number: BNKPL

CSD INC.

#5 HACKBURY LANE
CUT & SHOOT, TX 77303
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 409-756-1065

Preparer: DAVID SHIPP

Cage: JO933

MATHEWS, INC)

MATTHEWS, NC 28105-5073 US

Telephone: 704-821-9822

Cage: 5W216

METHYLENE CHLORIDE (SARA III) **PPM, 15

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: 25%

OSHA PEL 500 PPM/1000 PPM C

ACGIH TLV: 100 PPM/2000PPM-5MIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ALIPHATIC PETROLEUM DISTILLATES #15 MIN.

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 70%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

PERCHLOROETHYLENE (SARA III) *8 HR TWA

CAS: 127-18-4

RTECS: KX3850000

Fraction By Weight: 5%

OSHA PEL 100 PPM

ACGIH TLV: 25PPM/100,A3 STEL;94

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE: SEVERE
IRRIT/REDNESS/TEARING/BLURRED VISION. SKIN: MOD
IRRIT/DEFATTING/DERMATITIS. INHAL: EXCESS INHAL OF VAPORS CAN CAUSE
NASAL & RESP
IRRIT/DIZZINESS/WEAKNESS/FATIGUE/NAUSEA/HEADACHE/POSSIBLE U
NSCIOUSNESS/ASPHYXIATION. INGEST: GASTROINTESTINAL
IRRIT/NAUSEA/VOMITING/DIARRHEA. ASPIR OF MAT'L INTO LUNGS CAN
CAUSE**
Explanation of Carcinogenicity:METHYLENE CHLORIDE PRODUCED TUMORS IN
RATS BUT NOT IN HUMANS. PERCHLOROETHYLENE CAUSES LIVER CANCER.
Effects of Overexposure:CARDIOVASCULAR STRESS. BENIGN TUMORS/CANCER HAS
SHOWN UP IN RATS BUT NOT IN HAMPSTERS. LIVER ABNORMALITIES, KIDNEY
DAMAGE, LUNG DAMAGE AND BRAIN DAMAGE IN HUMANS.
**CHEMICAL PNEUMON ITIS WHICH CAN BE FATAL.

First Aid:EXTERNAL: WASH W/SOAP & WTR. RMV CONTAM CLOTHING & LAUNDER
BEFORE RE-USE. EYE: FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING
UPPER/LOWER LIDS OCCASIONALLY. GET MED AID. INGEST: DO NOT INDUCE
VOMITING. KE EP WARM/QUIET. GET PROMPT MED AID. INHAL: REMOVE TO
FRESH AIR. IF BREATH DIFFICULT, ADMIN OXYGEN. IF BREATH STOPPED,
GIVE ARTIFICIAL RESP. KEEP WARM/QUIET. GET IMMED MED AID. DO NOT
GIVE STIMULANTS.**

Lower Limits:1.0
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
CORROSIVE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN THE PRESSURE-DEMAND MODE OR OTHER
POSITIVE PRESSURE MODE WHEN LIGHTING FIRES.
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY). PROD (EVEN RESIDUE) CAN IGNIT EXPLO. VAPORS
HEAVIER THAN AIR, MAY TRAVEL ALONG GROUND/BY VENT &**

Spill Release Procedures:SMALL: ABSORB LIQUID ON
PAPER/VERMICULITE/FLOOR ABSORB/OTHER ABSORB MAT'L. LG: ELIM ALL
IGNIT SOURCES (FLARE/FLAME INCLUD PILOT LIGHT/ELEC SPARK/ETC). EVAC
AREA OF ALL UNPROTECTED PERSONS UNTIL CLEANU P COMPLETED. STOP
SPILL AT SOURCE, DIKEAREA OF*
Neutralizing Agent:N/K **EPINEPHRINE OR EPHEDRINE MAY ADVERSELY AFFECT
THE HEART W/FATAL RESULTS.

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL....SEE
SPECIAL PRECAUTIONS SECTION.

Respiratory Protection:NIOSH/MSHA APPROVED AIR SUPPLIED RESP IS ADVISED
IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REG ALSO PERMIT
OTHER NIOSH/MSHA RESP (NEGATIVE PRESS TYPE). UNDER SPECIFIED
CONDITIONS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NEOPRENE.
Eye Protection:CHEM SPLASH GOGGLES/SAFETY GLASSES.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING AND BOOTS.
Supplemental Safety and Health

HCC:T4
Boiling Pt:B.P. Text:102.9 F
Vapor Pres:340 MM HG
Vapor Density:> AIR
Spec Gravity:H2O-1 > 1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, LITTLE IF ANY COLOR, CHARACTERISTIC ODOR.
Percent Volatiles by Volume:100
Corrosion Rate:NOT

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:N/K **IGNITED BY HEAT/PILOT
LIGHTS/OTHER FLAMES/IGNIT SOURCES AT LOCATIONS DISTANT FROM
MATERIAL HANDLING POINT.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE AND CARBON MONOXIDE, HYDROGEN CHLORIDE, PHOSGENE, VARIOUS
HYDROCARBONS, ETC.

Waste Disposal Methods:N/K
*SPILL TO PREVENT SPREADING, PUMP LIQUID TO SALVAGE
TANK. REMAINING LIQUID MAY BE TAKEN UP ON SAND, CLAY, EARTH, FLOOR
ABSORBANT, OR OTHER A BSORBANT MATERIAL AND SHOVELED INTO
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.